|
MATERIALS SAFETY DATA SHEET |
| |||
| UNDER OSHA'S HAZARD COMMUNICATION STANDARD, WHERE COMPLEX MIXTURES HAVE SIMILAR HAZARDS AND CONTENTS, THE MANUFACTURER MAY PREPARE ONE MATERIAL SAFETY DATA SHEET TO APPLY TO ALL OF THESE SIMILAR MIXTURES. THIS DOCUMENT APPLIES TO ALL COLORS AND SPECIALS IN THIS INK LINE. | |||
|
SECTION I - INDENTITY |
| PRODUCT CODE : PX2 Poly-Xtreme LABEL INDENT : PX2 Poly-Xtreme SCREEN PRINTING INK PRODUCT CLASS : UV CURABLE SCREEN PRINTING INK LAST UPDATE: March 1, 2004 |
|
|
SECTION II (HAZARDOUS INGREDIENTS) |
 NE - NOT ESTABLISHEDUNKN - UNKNOWNTS - TRADE
SECRET *UNLESS NOTED OTHERWISE, THE UNITS ARE PPM AND mm hg @ 20 C, RESPECTIVELY, FOR EXPOSURE LIMITS AND VAPOR PRESSURE. N/A = NOT APPLICABLE N/D = NOT DETERMINEDUNKN = UNKNOWNT.S. =
TRADE SECRET THE PC-4000 SERIES IS FORMULATED TO BE N-VINYLPYRROLIDONE (NVP) FREE. | ||||||||||||
|
SECTION III - PHYSICAL & CHEMICAL CHARACTERISTICS |
| BOILING POINT / RANGE: > 150° C. VAPOR DENSITY : HEAVIER THAN AIR. DENSITY IS 9.10 TO 10.6 LBS / GAL. VOLATILE ORGANIC COMPOUNDS : NONE THE EVAPORATION RATE IS SLOWER THAN DIETHYL ETHER. | |
|
SECTION IV - PHYSICAL HAZARDS DATA) |
| FLAMMABILITY CLASSIFICATIONS : HMIS 1 OSHA : CLASS IIIB DOT : NOT REGULATED CLOSED CUP FLASH POINT : >200° F. EXPLOSION LIMITS : UNKNOWN EXTINGUISHING MEDIA : "CLASS B" FIRE EXTINGUISHERS USED PER INSTRUCTIONS "ALCOHOL" FOAM CO2DRY CHEMICALWATER FOG
USUAL FIRE AND EXPLOSION HAZARDS : KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE FROM HEAT, SPARKS, ELECTRICAL EQUIPMENT AND OPEN FLAMES. CLOSED CONTAINERS MAY RUPTURE OR EXPLODE WHEN EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES REQUIRES SPECIAL PRECAUTIONS, DURING EMERGENCY CONDITIONS, OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CONSTITUTE A HEALTH HAZARD. SYMPTOMS MAY NOT BE IMMEDIATELY APPARENT. OBTAIN MEDICAL ATTENTION. SPECIAL FIREFIGHTING PROCEDURES : FULL PROTECTION EQUIPMENT IS RECOMMENDED TO PROTECT FIRE FIGHTERS FROM ANY HAZARDOUS DECOMPOSITION PRODUCTS. WATER MAY BE UNSUITABLE FOR USE ON BURNING LIQUIDS. IF WATER MUST BE USED, FOG NOZZLES ARE HIGHLY PREFERABLE. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILD-UP AND POSSIBLE AUTO-IGNITION, EXPLOSION, OR RUPTURE WHEN EXPOSED TO EXTREME HEAT. | |
|
SECTION V - EMERGENCY & FIRST-AID PROCEDURES SIGNS & SYMPTOMS OF EXPOSURE & ROUTES OF ENTRY |
| PRIMARY ROUTES OF ENTRY ARE DERMAL. SWALLOWING : MODERATELY TOXIC. MAY CAUSE IRRITATION OF THE MOUTH, THROAT , ESOPHAGUS AND STOMACH. THERE MAY BE DISCOMFORT OR PAIN IN THE MOUTH, THROAT, CHEST AND ABDOMEN, WITH NAUSEA, VOMITING, DIARRHEA, DIFFICULTY SWALLOWING, WEAKNESS, THIRST, DIZZINESS AND DROWSINESS. ASPIRATION INTO THE LUNGS MAY OCCUR DURING INGESTION OR VOMITING, RESULTING IN LUNG INJURY. DRINK TWO GLASSES OF WATER TO DILUTE. DO NOT INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. CONSULT PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. TREAT SYMPTOMATICALLY. BE PREPARED TO PROVIDE THE ATTENDING PHYSICIAN WITH A COPY OF THIS DOCUMENT. SKIN CONTACT : CONTAINS MATERIAL THAT MAY CAUSE SEVERE SKIN IRRITATION (REDDENING AND SWELLING) AND/OR SENSITIZATION. PROLONGED CONTACT MAY CAUSE BLISTER FORMATION (BURNS). SINCE IRRITATION MAY NOT OCCUR IMMEDIATELY, CONTACT CAN GO UNNOTICED. REMOVE CONTAMINATED CLOTHING. WASH SKIN THOROUGHLY WITH MILD SOAP AND WARM WATER. CONSULT A PHYSICIAN IF THERE IS ANY PERSISTING IRRITATION. SKIN ABSORPTION : NO SPECIFIC INFORMATION AVAILABLE. CONTAINS MATERIALS THAT MAY BE SLIGHTLY TOXIC. INHALATION : EXPOSURE TO VAPORS IS UNLIKELY DUE TO LOW VAPOR PRESSURE OF INGREDIENTS, BUT INHALATION OF MIST, AEROSOLS, OR VAPORS MAY RESULT IN IRRITATION OF RESPIRATORY TRACT, COUGHING, SHORTNESS OF BREATH AND DIZZINESS. REMOVE VICTIM TO A WELL VENTILATED AREA. GIVE OXYGEN OR ARTIFICIAL RESPIRATION AS REQUIRED. TREAT SYMPTOMATICALLY AND CONSULT PHYSICIAN. EYE CONTACT : CONTAINS MATERIALS THAT MAY CAUSE MODERATE IRRITATION, INCLUDING BURNING SENSATION, TEARING, REDNESS OR SWELLING. FLUSH WITH COPIOUS AMOUNTS OF WATER FOR A LEAST FIFTEEN MINUTES. CONSULT PHYSICIAN. MEDICAL CONDITIONS KNOWN TO BE AGGRAVATED BY OVEREXPOSURE : LUNG CONDITIONS, SENSITIZATION, OR ALLERGIES, SKIN AND EYE CONDITIONS. CHRONIC EFFECTS : MAY CAUSE SKIN SENSITIZATION. DERMATITIS. ACRYLATES HAVE BEEN REPORTED TO BE MUTAGENIC ONLY IN THE MOUSE LYMPHOMA ASSAY, BUT NEGATIVE IN THE AMES TEST. ADDITIONAL KNOWN HEALTH HAZARDS : NO DATA FOUND SPECIAL NOTES TO ATTENDING PHYSICIAN : THERE IS NO SPECIFIC ANTIDOTE. TREATMENT OF OVEREXPOSURE SHOULD BE DIRECTED AT CONTROL OF THE SYMPTOMS AND THE CLINICAL CONDITION. | |
|
SECTION VI - REACTIVITY DATA |
| THIS MIXTURE IS POTENTIALLY UNSTABLE AND HAZARDOUS POLYMERIZATION
MAY OCCUR IF EXPOSED TO MATERIALS AND CONDITIONS TO BE AVOIDED.
INCOMPATIBILITY (MATERIALS TO AVOID) : STRONG ACIDS, OXIDIZERS, ALKALI, METAL HYDROXIDES, POLYMERIZATION INITIATORS, PEROXIDES, INERT GASES, PRIMARY AND SECONDARY AMINES. HAZARDOUS DECOMPOSITION PRODUCTS : CARBON MONOXIDE, CARBON DIOXIDE, MIXED OXIDES OF NITROGEN, SULFUR AND METHACRYLATE MONOMERS. CONDITIONS TO AVOID : EXTREME TEMPERATURES, DIRECT SUNLIGHT, X-RAY SOURCES, ELECTRON BEAM SOURCES, OR ULTRAVIOLET RADIATION SOURCES. | |
|
SECTION VII - SPILL & LEAK PROCEDURES |
| PRECAUTIONS IF MATERIAL IS SPILLED OR RELEASED : PLACE LEAKING
CONTAINERS IN A WELL VENTILATED AREA,. AVOID BREATHING VAPORS. ELIMINATE
ALL SOURCES OF HEAT, AS WELL AS ALL CONDITIONS NOTED IN SECTION VI ABOVE.
NOTIFY PROPER AUTHORITIES IF PUBLIC WATERS OR SEWERS ARE CONTAMINATED.
WASTE DISPOSAL METHODS : AS A HAZARDOUS WASTE, THIS MATERIAL MUST BE DISPOSED OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL ORDINANCES. INQUIRE OF YOUR LOCAL ENVIRONMENTAL AGENCIES FOR THE EXACT LEGAL REQUIREMENT IN YOUR AREA. REFER TO SECTIONS IV, V, VI, VII AND VIII OF THIS DOCUMENT BEFORE ATTEMPTING ANY CLEANUP. | |
|
SECTION VIII - SAFE HANDLING AND USE INFORMATION |
| RESPIRATORY PROTECTION : DO NOT BREATHE VAPORS OR SPRAY MISTS.
WEAR AN APPROPRIATE, PROPERLY FITTED RESPIRATOR (NIOSH/OSHA APPROVED)
DURING AND AFTER APPLICATION UNLESS AIR MONITORING DEMONSTRATES VAPOR/MIST
LEVELS ARE BELOW APPLICABLE LIMITS. FOLLOW RESPIRATOR MANUFACTURER'S
DIRECTIONS FOR RESPIRATOR USE. VENTILATION REQUIREMENTS : LOCAL EXHAUST RECOMMENDED WHEN APPROPRIATE TO CONTROL EXPOSURE TO MIST OR AEROSOLS. GENERAL EXHAUST IS NORMALLY ADEQUATE TO MINIMIZE EXPOSURE TO VAPORS. PROTECTIVE GLOVES : RUBBER OR NEOPRENE TO MINIMIZE SKIN CONTACT. EYE PROTECTION : SAFETY GOGGLES OR FULL FACT SHIELD WHENEVER A SPLASH HAZARD IS PRESENTED. HYGIENIC SAFETY PRACTICES : WASH HANDS BEFORE EATING, USING TOBACCO PRODUCTS, OR USING THE WASHROOM. TOBACCO AND FOOD SHOULD BE CONSUMED IN DESIGNATED AREAS ONLY. ADDITIONAL SAFETY EQUIPMENT : IMPERMEABLE APRONS AND BOOTS. SAFETY SHOWER AND EYE BATH SHOULD BE MADE AVAILABLE. | |
|
SECTION IX - SPECIAL PROCEDURES |
| TRANSPORTATION, STORAGE AND HANDLING : AVOID CONDITIONS LISTED IN
SECTION VI. AVOID PROLONGED STORAGE AT TEMPERATURES IN EXCESS OF 100 °F.
OTHER PRECAUTIONS : LEATHER GLOVES, APRONS, BELTS OR BOOTS MAY BE PERMEATED BY THESE MATERIALS, CAUSING DELAYED AND PERSISTENT IRRITATION CHEMICAL BURNS. LEATHER ITEMS SHOULD BE DISPOSED OF, ONCE CONTAMINATED. | |
|
SECTION X - DISCLAIMER |
| INK SOURCE, INC. MAKES NO WARRANTY, EXPRESSED OR IMPLIED, AS TO THE ACCURACY OR RELIABILITY OF INFORMATION CONTAINED HEREIN, EXCEPT THAT SUCH INFORMATION IS, TO THE BEST OF INK SOURCE'S KNOWLEDGE AND BELIEF, ACCURATE AS OF THE DATE INDICATED ON THIS DOCUMENT. FINAL DETERMINATION OF SUITABILITY OF ANY MATERIAL IS THE SOLE RESPONSIBILITY OF THE USER. ALL MATERIALS MAY PRESENT UNKNOWN HEALTH HAZARDS AND SHOULD BE USED WITH CAUTION. ALTHOUGH CERTAIN HAZARDS ARE DESCRIBED HEREIN, WE CANNOT GUARANTEE THAT THESE ARE THE ONLY HAZARDS THAT EXIST. | |
|
SECTION XI - PURCHASERS' OBLIGATIONS |
| INK SOURCE, INC URGES THE CUSTOMER RECEIVING THIS MATERIAL SAFETY DATA SHEET TO STUDY IT CAREFULLY TO BECOME AWARE OF HAZARDS, IF ANY, OF THE PRODUCTS INVOLVED. IN THE INTEREST OF SAFETY, YOU SHOULD ( 1 ) NOTIFY YOUR EMPLOYEES, AGENTS AND CONTRACTORS OF THE INFORMATION ON THIS SHEET, ( 2 ) FURNISH A COPY TO EACH OF YOUR CUSTOMERS FOR THIS PRODUCT, AND ( 3 ) REQUEST YOUR CUSTOMERS TO INFORM THEIR EMPLOYEES, CUSTOMERS AND AGENTS, AS WELL. | |
|
SECTION XII - REGULATORY INFORMATION |
| TOXIC SUBSTANCES CONTROL ACT ( TSCA ) STATUS : THE INGREDIENTS OF
THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY. SARA TITLE III SECTION 313 INFORMATION : THIS PRODUCT DOES NOT CONTAIN TOXIC CHEMICALS SUBJECT TO THE ANNUAL REPORTING REQUIREMENTS OF SECTION 313 OF THE TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372. STATE OF CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986 ( PROPOSITION 65) : THIS PRODUCT DOES NOT CONTAIN CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER OR REPRODUCTIVE TOXICITY. | |